Trusted ac repair for Hillsborough properties. Same-day service available, transparent pricing, and a workmanship guarantee.
KIC Refrigeration delivers expert air conditioning repair in Hillsborough, NC, diagnosing compressor failures, refrigerant leaks, frozen evaporator coils, and electrical faults using superheat, subcooling, and amp draw measurements. Our EPA Section 608 certified technicians restore rated SEER output through manufacturer-guided repair procedures across all major AC brands.
Properties throughout Hillsborough (pop. 9,831) face unique demands when it comes to ac repair. North Carolina heating loads, cooling calculations, and the insulation levels and duct configurations found in Hillsborough homes all influence the approach we take. KIC Refrigeration tailors every ac repair project to the conditions your property actually faces — no generic solutions.
Choosing the right contractor for ac repair in Hillsborough, NC makes all the difference between efficient comfort and a system that short-cycles. KIC Refrigeration uses Manual J load calculations, installs to manufacturer specifications, and backs every project with a warranty. Call (866) 858-2961 to schedule your free assessment.
From initial contact to final verification — here is how we handle ac repair.
KIC Refrigeration begins every AC repair in Hillsborough, NC with a systematic assessment. We verify 24-volt control voltage at the thermostat, check high and low voltage wiring for damage, inspect the disconnect for burned contacts, confirm the breaker is properly sized, and visually inspect both indoor and outdoor units before powering up the system for testing.
We test capacitors, contactors, relays, and the compressor windings with a multimeter. We connect manifold gauges to measure suction and discharge pressures, calculate superheat and subcooling, and compare all readings to the manufacturer specification for your unit.
Our Hillsborough technician replaces the failed part with the correct replacement for your unit make, model, and tonnage. If the failure involves the sealed refrigerant system, we recover the charge, make the repair, pressure test with nitrogen, evacuate to below 500 microns, and weigh in the correct charge of R-410A or the specified refrigerant.
KIC Refrigeration verifies every AC repair in Hillsborough, NC with a comprehensive performance test. We confirm temperature split, superheat, subcooling, compressor amperage, condenser fan amperage, blower CFM, and thermostat operation. We document all readings and explain the results before we consider the job complete.
Transparent answers about ac repair from our certified technicians.
AC repair in Hillsborough typically costs $150 to $500 for common component failures including run capacitors ($150 to $250), contactors ($150 to $350), condenser fan motors ($250 to $500), and blower motors ($300 to $600). Compressor replacement is the most expensive repair at $1,500 to $3,500 depending on unit tonnage and whether the system uses R-410A or older R-22 refrigerant. Evaporator coil replacement runs $800 to $2,500 including the refrigerant recovery and recharge. KIC Refrigeration provides a detailed written estimate with itemized parts and labor costs before beginning any AC repair at your Hillsborough property so there are no surprises on the invoice.
The industry guideline is to repair if the unit is under 10 years old and the repair costs less than 50 percent of a new system. AC units over 15 years old — especially those running R-22 refrigerant — are almost always better replaced. R-22 has been phased out of production and the remaining supply costs $80 to $150 per pound, making even minor refrigerant leaks prohibitively expensive to fix. A new 16 SEER2 system uses approximately 38 percent less energy than a 10 SEER unit, and many qualify for the federal energy tax credit. KIC Refrigeration helps Hillsborough homeowners evaluate repair versus replacement based on equipment age, repair history, refrigerant type, and projected energy savings.
AC refrigerant recharge in Hillsborough costs $200 to $500 for R-410A systems at roughly $50 to $80 per pound, and $400 to $1,200 for older R-22 systems at $80 to $150 per pound due to the phaseout-driven supply shortage. However, simply adding refrigerant without finding the leak is a temporary and wasteful fix — the charge will leak out again in weeks or months and you will be back in the same situation. KIC Refrigeration always locates the leak first using electronic leak detectors and UV dye, repairs the leaking component, evacuates the system to remove moisture and air, and recharges by weight to the manufacturer specification. This approach fixes the problem permanently.
Yes. KIC Refrigeration offers same-day AC repair in Hillsborough for the majority of service calls received before early afternoon. Our service vehicles carry over 200 common AC parts including capacitors in multiple ratings, contactors, condenser fan motors, blower motors, hard-start kits, control boards, and R-410A refrigerant — enabling us to complete most repairs during the initial visit without waiting on parts orders. We understand that losing air conditioning in Hillsborough during summer heat is more than a comfort issue, particularly for elderly residents, young children, and people with respiratory conditions. KIC Refrigeration prioritizes fast response and first-visit resolution for every Hillsborough AC repair call.
Hear from property owners who chose us for their heating and cooling needs.
"They installed a new AC unit for us and it has been running flawlessly all summer. Quiet, efficient, and the install crew was great to work with."
"AC repair was fast and fairly priced. The compressor was failing and they had the part on the truck. Done in about ninety minutes."
"Boiler repair took a couple visits because they needed to order a part, but they were upfront about it and the repair has held up perfectly."